Search
Filters
$499.99 plus s/h. Parts and housing repairs, if needed, are additional.
SKU: 17-TRUR-dg
Make: DODGE
Call for availability
This service includes complete dismantling of your original trunk unit. All parts are stripped, glass beaded and repainted and/or plated to original finish. evaporator is reconditioned, all vacuum actuators and switches are cleaned and tested, new seal are installed and the unit is reassembled. The unit comes back to you restored and ready to install. Note - Additional parts and/or metal/fiberglass repairs, if needed, are additional.
This service includes complete dismantling of your original trunk unit. All parts are stripped, glass beaded and repainted and/or plated to original finish. evaporator is reconditioned, all vacuum actuators and switches are cleaned and tested, new seal are installed and the unit is reassembled. The unit comes back to you restored and ready to install. Note - Additional parts and/or metal/fiberglass repairs, if needed, are additional.

CONVERTING MOPARS TO 134a

Until 1995, most cars with air conditioning used R-12 Freon refrigerant that is said to have a negative side effect of damaging the ozone layer and is no longer produced in most countries. since then, the industry standard has been R134a, which is an efficient replacement.  Contrary to popular belief, most cars originally equipped with R-12 can be converted to 134a and still keep you just as cool.

1962 & Newer Systems - Minimum Requirements

  • Change or restore the filter-drier.

  • Drain the compressor oil and recharge with 134a compatible oil. (PAG or Ester Oil)

  • Insure that the system is clean and free of contaminants (Depending on component condition, this may be a simple matter of blowing out with compressed air or liquid flushing with an air-conditioning flushing agent)

  • Replace or restore all rubber hoses with barrier hose.

  • Remove EPR valve from compressor’s suction port

  • Install thermostat.

  • Charge with 134a between 70-80% of the original R12 charge amount.

  • Replace any o-rings with 134a compatible.

HELPFUL HINTS

  • Ignore the sight-glass. A properly charged 134a system will likely show bubbles in the sight-glass.

  • Typical 134a charge rate will be approximately 70-80% of the factory R12 charge amount.

Products specifications
Model CORONET
Model MONACO
Model POLARA
Years 55
Years 56
Years 57
Years 58
Years 59
Years 60
Years 61
Years 62
Years 63
Years 64
Category SERVICES
Category EVAPORATOR UNIT PARTS
Manufacturer DODGE
Product tags